全国咨询热线
冻肉切片机能将冻肉直接进行切割，加工过程中不需求解冻，即省去了冻肉的缓化时刻，又避免了因缓化造成的肉质污染，多用于肉食品加工企业。今天，来了解冻肉切片机是如何操作的吧！
Frozen meat slicer can cut frozen meat directly without thawing during processing, which saves the time of thawing of frozen meat and avoids meat pollution caused by thawing. It is mostly used in meat processing enterprises. Today, let's learn how to operate the frozen meat slicer!
1、要打开电源指示灯下方的开关。
1. First, turn on the switch under the power indicator.
2、由于只有把气缸护罩和前门关好机器才可以正常发动，所以我们在使用之前需进行检查。
2. Since the machine can only be started normally when the cylinder cover and front door are closed, we need to check before use.
3、按下发动按钮，切割滚筒开端旋转并接通一切电器和气动控制。
3. Press the start button, the cutting drum starts to rotate and turn on all electrical and pneumatic control.
4、将把需求加工的冻肉平整面向下放进料道内，然后按下进料按钮，推料器开端推着肉块向前移动，一起进行切割。
4. Put the flat surface of frozen meat to be processed down into the feeding channel, then press the feeding button, and the pusher starts to push the meat forward to cut together.
5、根据自身条件调整计时器，推料器可自动推料及退回。
5. Adjust the timer according to its own conditions, the pusher can push and return automatically.
6、推料器的速度可用坐落机器后部的节流阀2调整，但是进给的速度不能过快。
6. The speed of the pusher can be adjusted by the throttle valve 2 located at the rear of the machine, but the feeding speed cannot be too fast.
7、要彻 底中止机器可按下中止按钮，机器将彻 底中止。机器中止后不要立即打开顶盖及前门，应等切割滚筒彻 底中止后才能打开。
7. To stop the machine completely, press the stop button and the machine will stop completely. Do not open the top cover and front door immediately after the machine is stopped, but wait until the cutting roller is completely stopped.
8、使用前，先查看机器各部分有无缺损，然后把冻肉绞肉机清洗干净。
8. Before use, check whether there is any defect in each part of the machine, and then clean the frozen meat grinder.
9、接通电源，若电源灯亮，则说明接线正确，注意接地。
9. Turn on the power. If the power light is on, it means that the wiring is correct. Pay attention to the grounding.
10、开启机器，将切割成小块的冻肉放入冻肉绞肉机的料箱内，冻肉块由送料绞龙送绞刀处绞切，当肉颗粒小于孔板的孔径时，即可从孔板处出料。
10. Start the machine, put the frozen meat cut into small pieces into the material box of the frozen meat grinder. The frozen meat pieces are sent to the cutter by the feeding auger for cutting. When the meat particles are smaller than the hole diameter of the orifice plate, they can be discharged from the orifice plate.
11、严禁将带有骨头或其他杂物的肉块放入冻肉绞肉机内，以防损坏设备；不能将手伸进冻肉绞肉机中，以防发生意外。
11. It is strictly forbidden to put meat pieces with bones or other sundries into the frozen meat grinder to prevent damage to the equipment; Do not put your hand into the frozen meat grinder to prevent accidents.
12、使用后应彻 底清洗冻肉绞肉机的各个部件。
12. All parts of the frozen meat grinder should be cleaned thoroughly after use.
